装载机蓄电池一直是装载机不可少的组成部分，通过蓄电池可以为车载用电设备供电，驱动启动马达，带动发动机启动等重要作用。那么装载机蓄电池使用时应该注意哪些问题呢？

1、装载机蓄电池的加液孔盖上一般都会设计有通气孔，在平时的使用过程中应经常检查这些通气孔，并始终保证其畅通。如果通气孔不畅通的话，在进行充放电过程时，因蓄电池内发生的化学反应所产生的气体无法及时排出，就会导致蓄电池鼓爆，引起蓄电池内部结构损坏，从而造成不必要的损失。
Dosing hole Shandong loaders batteries usually designed with a vent cover, in the usual course should always check the vent, and always ensure their smooth. If the vent is not blocked, then,during the charge and discharge process, the gas due to chemical reaction occurring within the battery can not be discharged generated, it will lead to a battery explosion drum, causing damage to the internal structure of the battery, resulting in unnecessary losses.

2、装载机蓄电池的极柱要保持清洁，供电线路连接要牢固，要及时除去极柱和连接线头处的氧化物。笔者在文章开头就说了，如果连接不牢固或者因锈蚀造成极柱与接线接触不良，就会对充电造成到很大的影响，使用起来也会降低蓄电池的使用寿命。
Shandong loader battery pole to keep clean, power lines connected to a solid, to promptly remove the oxide pole and connecting thread at. I said at the beginning of the article, if the connection is not secure or due to corrosion caused by the pole and wiring is bad, it will cause the charge to a great impact, using them will reduce battery life.

3、装载机要防止蓄电池短路。在此需要特别注意，金属器件一定不能放在蓄电池上，如钳子、扳手、改锥等这些常用的金属工具，因为金属器件与蓄电池极柱连接并与金属机身搭铁后，会形成一个闭合回路，造成蓄电池短路，从而烧坏蓄电池，导致蓄电池报废。另外，蓄电池上如果有污水或者脏物也应该及时清除，因为这些杂物也会导致蓄电池短路，使蓄电池发生损坏。
Shandong loader to prevent battery short circuit. Require special attention in this, the device must not be placed on metal batteries, such as pliers, wrenches, screwdrivers and other tools commonly used metals such as metal device is connected to the battery pole and rear metal body grounding, will form a closed loop , resulting in a battery short circuit, which burn batteries, lead battery scrap. In addition, if there is water on the battery or dirt should be promptly removed, because the debris will cause a short circuit the battery, so that the battery is damaged.

4、装载机蓄电池应该定期检查电解液是否充足。蓄电池电解液不足会使极板硫化，蓄电池容量降低。另外极板硫化的另一个重要原因就是蓄电池存电不足，存电不足还会造成蓄电池电气性能降低，缩短使用寿命。
Shandong loaders should regularly check the battery electrolyte is sufficient. Battery electrolyte deficiencies would plate curing, the battery capacity decreases. In addition, another important reason is that the battery plate curing to save electricity, save electricity shortage will result in reduced battery electrical performance and shorten life.

5、装载机蓄电池的日常保养。蓄电池如果超过一周以上的时间不用，应考虑对蓄电池进行断电，如果蓄电池有开关，则应该断开蓄电池开关。蓄电池如果长期不用，应将电解液调整到标准刻度线位置，并对蓄电池电量充满。
Shandong loader routine maintenance batteries. Battery time if not more than a week, you should consider the battery to power, if the battery has a switch, you should disconnect the battery switch. If the long-term without the battery, the electrolyte should be adjusted to the standard position of the mark, and the battery is fully charged.